内养护剂和膨胀剂组合对混凝土收缩的影响
作者:
作者单位:

1.中冶建筑研究总院有限公司,北京 100088;2.北京科技大学 城镇化与城市安全研究院, 北京 100083;3.中国矿业大学(北京) 力学与建筑工程学院,北京 100083

作者简介:

韩宇栋(1986—),男,安徽安庆人,中冶建筑研究总院高级工程师,硕士生导师,博士. E-mail:hanyudong@cribc.com

通讯作者:

韩宇栋(1986—),男,安徽安庆人,中冶建筑研究总院高级工程师,硕士生导师,博士. E-mail:hanyudong@cribc.com

中图分类号:

TU528

基金项目:

国家自然科学基金资助项目(52178263);北京市科技新星计划(Z201100006820024)


Effect of Internal Curing Agent and Expansion Agent on Concrete Shrinkage
Author:
Affiliation:

1.Central Research Institute of Building and Construction, MCC Group Co., Ltd., Beijing 100088, China;2.Research Institute of Urbanization and City Safety, University of Science and Technology Beijing, Beijing 100083, China;3.School of Mechanics and Civil Engineering, China University of Mining and Technology (Beijing), Beijing 100083, China

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    为在等抗压强度前提下调控混凝土的早期收缩开裂,以膨胀剂(HP-CSA)和由高吸水树脂(SAP)引入的内养护水占胶凝材料相同比例进行组合,设计了各自的内掺量均为0%、4.5%、6.0%、9.0%共4种混凝土配合比,研究了其对混凝土早期收缩的调控规律,并分析了混凝土收缩、力学强度、内部相对湿度和干燥失水率之间的关系.结果表明:混凝土早期收缩和内部相对湿度发展均呈2阶段规律;随“HP-CSA+SAP”组合掺量增加,其对混凝土早期收缩的调控作用逐渐增强,且在阶段I的调控作用更为显著,但28 d时仍不能根除混凝土的净干燥收缩;组合掺量对混凝土早期内部湿度发展的整体影响较小;混凝土28 d内的净干燥收缩与干燥失水率之间基本呈线性正相关.从调控收缩、强度保持和经济性等方面综合考虑,6.0%为最优调控组合掺量.

    Abstract:

    To control early-age shrinkage induced cracking for concrete with equivalent compressive strength, four concrete mixtures were prepared with co-addition of expansion agent (HP-CSA) and internal curing water introduced by superabsorbent polymer (SAP), both of them at the rate of 0%, 4.5%, 6.0% and 9.0% by mass to the dosage of total cementitious materials. The regulation effect of "HP-CSA+SAP" combination on early-age shrinkage of concrete was experimentally investigated. The relationships between shrinkage, mechanical strength, internal relative humidity and water loss rate during drying of concrete were analyzed. The test results show that the developments of early-age shrinkage and internal relative humidity of concrete both follow a two-stage rule. The more the dosage of "HP-CSA+SAP" combination, the better the controlling effect on early-age concrete shrinkage, especially in shrinkage developing stage I. However, as the net drying shrinkage of concrete could not be completely eliminated in 28 d, the influence of the combination dosage of "HP-CSA+ SAP" on the development of early-age internal humidity of concrete is relatively small. The net drying shrinkage of concrete is positively linearly correlated to the water loss rate within 28 d. Considering the performances in shrinkage reducing, strength retention and cost-effectiveness, 6.0% is considered to be the optimal dosage of "HP-CSA+SAP" combination.

    参考文献
    相似文献
    引证文献
引用本文

韩宇栋,李威,岳清瑞,谢月,刘子祎.内养护剂和膨胀剂组合对混凝土收缩的影响[J].建筑材料学报,2023,26(6):604-611

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2022-08-04
  • 最后修改日期:2022-09-27
  • 录用日期:
  • 在线发布日期: 2023-07-06
  • 出版日期: