水泥石灰石粉浆体颗粒群特性与流变性能关系
作者:
作者单位:

作者简介:

通讯作者:

中图分类号:

基金项目:

国家自然科学基金资助项目(51278497);中南大学研究生自主探索创新项目(2019zzts969)


Relationship between Particle Characteristics and Rheological Properties of Cement Limestone Powder Pastes
Author:
Affiliation:

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    采用RHEOLAB QC型旋转黏度计测定水泥石灰石粉浆体的流变性能,研究了颗粒群特性(粒径分布和堆积密度)与浆体流变性能的关系,并在此基础上探究了颗粒水膜厚度与浆体流变性能的关系.结果表明:石灰石粉掺入水泥浆体中使颗粒分布变广,颗粒堆积状态得以改善;粒径分布系数与浆体屈服应力、稠度的线性相关性不高,相关系数仅为060061和069962;颗粒堆积密度与浆体屈服应力、稠度呈负线性相关,相关系数分别为083058和084654;颗粒堆积密度与浆体流变性能的相关性高于粒径分布系数;颗粒水膜厚度与浆体流变性能不呈简单线性关系,其中对于掺细度411m2/kg石灰石粉的水泥浆体,其屈服应力和稠度减小,颗粒水膜厚度增大;对于掺细度807、1007m2/kg石灰石粉的水泥浆体,其屈服应力和稠度减小,颗粒水膜厚度先增后减,出现了屈服应力、稠度和颗粒水膜厚度同时减小的现象.

    Abstract:

    Yield stress and consistency of cement limestone powder pastes were measured by RHEOLAB QC rotational viscometer. The relationship between particle size distribution, packing density and rheological properties was studied. The results show that the addition of limestone powder makes the particle distribution wider and improvement of the state of particle accumulation. The linear correlation between particle size distribution coefficient and yield stress and consistency is not close, the correlation coefficient is only 060061 and 069962 The correlation coefficient between the packing density and the yield stress and consistency is 083058 and 084654, which is closer than that of the particle size distribution coefficient. The relationship between water film thickness and rheological properties cannot be described by linear function, among which the yield stress and consistency of the cement paste with 411m2/kg limestone powder are decreased and the water film thickness is increased. The yield stress and consistency of the cement paste adding limestone fineness powder of 807, 1007m2/kg decrease, the water film thickness first increases and then decreases, and the yield stress, consistency and water film thickness decrease simultaneously.

    参考文献
    相似文献
    引证文献
引用本文

肖佳,张泽的,韩凯东,田承宇,邱凯.水泥石灰石粉浆体颗粒群特性与流变性能关系[J].建筑材料学报,2021,24(1):7-13

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2019-07-10
  • 最后修改日期:2019-10-10
  • 录用日期:
  • 在线发布日期: 2021-03-09
  • 出版日期: